Brand: Clymer

Quick Reference Data

CHAPTER ONE / GENERAL INFORMATION

CHAPTER TWO / TROUBLESHOOTING

CHAPTER THREE / LUBRICATION, MAINTENANCE AND TUNE-UP
Operational checklist / Break-in / Ten-hour inspection / Lubrication / Engine oil tank / Jet pump impeller housing oil change / PTO flywheel and seal carrier lubrication / Counterbalance shaft oil / Periodic maintenance / Fuel filter / Oil injection filter / Engine drain tube / Intake grate / Impeller / Drive shaft boots and splines / Flame arrestor / Oil tank / Control cable lubrication / Tune-up / Torque cylinder head / Cylinder compression / Spark plug / Ignition timing / Idle speed / Fuel injection adjustment / Off-season storage / Specifications

CHAPTER FOUR / ENGINE
Engine rotation / Engine lubrication / Servicing engine in hull / Engine removal / Engine support and rubber mounts / Engine installation / Jet pump engine alignment / Exhaust pipes and manifold / Engine top end / Cylinders / Piston, pin and rings / Crankcase and crankshaft / Rotary valve and shaft / Air compressor / PTO flywheel / Specifications

CHAPTER FIVE / DRIVE SYSTEM
Jet pump / Jet pump installation / Drive shaft boot and floating seal / Mid-bearing / Variable trim system / Reverse system / Specifications

CHAPTER SIX / FUEL SYSTEM CARBURETED
Fuel system identification / Air intake silencer and flame arrester / Carburetor / Carburetor pressure testing / Fuel tank / Fuel valve / Fuel pickup and sensor / Fuel system pressure test / Specifications

CHAPTER SEVEN / FUEL INJECTION SYSTEM
Fuel system identification / Air silencer and flame arrester / Throttle body / Fuel injection system sensors / Fuel rail and fuel injectors / Air/fuel/rail, regulators and injections / Fuel pressure regulator / Fuel tank / Fuel pump and sensor / Air compressor / Fuel system pressurization / Specifications

CHAPTER EIGHT / ELECTRICAL SYSTEM
Battery / Charging system / Electric starting system / Flywheel and stator plate / Flywheel and stator / Magneto housing / Electrical junction boxes and MPEM modules / Switches / Fuel level sensor / LCD fuel gauge / Oil level sensor / Speedometer and speed sensor / Tachometer / Variable trim system gauge VTS / Information center / Fuses / Wiring diagrams / Specifications

CHAPTER NINE / OIL INJECTION SYSTEM
System components / Oil pump service / Component replacement / Oil pump / Specifications

CHAPTER TEN / COOLING SYSTEM
Cooling system operation / Cooling system identification / Hose and hose fitting replacements / Hose clamps / Engine drain hose / Cooling system flushing / Water flow regulator valve / Specifications

CHAPTER ELEVEN / STEERING SYSTEM
Handlebar grips / Handlebar cover / Steering stem / Steering cable replacement / Handlebar alignment / Specifications

INDEX

WIRING DIAGRAMS

Models Covered
1997-2001 Sea-Doo GS
1997-2001 Sea-Doo GSI
1997-2001 Sea-Doo GSX
1997-2001 Sea-Doo GSX Limited
1997-2001 Sea-Doo GSX RFI
1997-2001 Sea-Doo GTI
1997-2001 Sea-Doo GTS
1997-2001 Sea-Doo GTX
1997-2001 Sea-Doo GTX DI
1997-2001 Sea-Doo GTX Limited
1997-2001 Sea-Doo GTX RFI
1997-2001 Sea-Doo HX
1997-2001 Sea-Doo LRV
1997-2001 Sea-Doo RX
1997-2001 Sea-Doo RX DI
1997-2001 Sea-Doo SP
1997-2001 Sea-Doo SPX
1997-2001 Sea-Doo XP
1997-2001 Sea-Doo XP Limited

Part Number Variations
W810
W-810
156-W810
6209293