CHAPTER THREE / LUBRICATION, MAINTENANCE AND TUNE-UP
Before each use / After each use / Lubrication / Fuel system maintenance /
Engine coolant / Tune-up / Submersion / Specifications
CHAPTER FOUR / LAY-UP, WINTERIZING AND FITTING OUT
Lay-up / Winterizing / Fitting out
CHAPTER FIVE / ADJUSTMENTS
Carburetor adjustment / Ignition timing adjustment / Shift cable adjustment /
Throttle cable adjustment / Trim position sender and trim limit control module
adjustment / Specifications
CHAPTER SIX / ENGINE
Engine operation / Special tools / Replacement parts / Special service
precautions / Engine removal / Engine installation / Engine alignment / Rocker
arm cover / Valve adjustment / Placing the No. 1 piston at TDC (firing position)
/ Lifter cover / Measuring camshaft lobe lift / Cylinder head / Valves and valve
seats / Rocker arm and pushrod / Flywheel housing, drive coupler and flywheel /
Oil pan / Oil pump / Harmonic balancer / Timing gear or chain cover and oil seal
/ Timing chain and sprockets / Balance shaft / Camshaft and lifters / Piston and
connecting rod / Crankshaft and rear main seal / Break-in procedure /
Specifications
CHAPTER SEVEN / FUEL SYSTEM
Servicing the fuel system / Mechanical low-pressure fuel pump / Low-pressure
electric fuel pump / Flame arrestor and cover / Carburetor / Electronic fuel
injection (EFI) / Throttle body / Intake plenum, fuel rail and injectors / Fuel
pressure regulator / High-pressure electric fuel pump / Fuel reservoir / Intake
manifold / Specifications
CHAPTER EIGHT / COOLING AND EXHAUST SYSTEMS
Thermostat / Hose replacement / Recirculation pump replacement / Seawater pump /
Oil and power steering fluid coolers (replacement) / Exhaust elbow / Exhaust
bellows, exhaust tube and flapper valve / Exhaust manifold / Specifications
CHAPTER NINE / ELECTRICAL SYSTEM
Battery / Alternator / Starter and starter solenoid / Ignition system / Starter
slave solenoid / Starter relay / Fuel pump relay / Electronic fuel injection
(EFI) system relay / Oil pressure sender / Oil pressure switch / Coolant
temperature sender / Coolant temperature sensor / Engine overheat switch /
Manifold air pressure sensor / Intake air temperature (IAT) sensor / Throttle
position sensor (TPS) / Idle air control motor (IAC) / Idle speed control
solenoid (ISC) / Knock sensor (KS) / Knock sensor module / Knock sensor
amplifier / Engine control unit (ECU) / Engine control assembly (ECA) /
Specifications
CHAPTER TEN / DRIVE UNIT
Drive unit identification / Drive unit operation / Drive unit gear ratio / High
altitude operation / Outdrive service precautions / Sacrificial anodes /
Shifting and propeller rotation / Propeller / Drive unit / Universal joint
service / Shift housing service / Lower gearcase / Drive unit pressure and
vacuum tests / Specifications
CHAPTER ELEVEN / TRANSOM BRACKET
Pivot housing / Bellows and water hose / Gimbal bearing and seal / Gimbal ring /
Inner transom plate and bracket housing / Specifications
CHAPTER TWELVE / POWER TRIM SYSTEM
Electrical trim system components / Hydraulic trim system components / Trim
cylinder and hoses / Trim position sender / Filling and bleeding the trim system
/ Specifications
CHAPTER THIRTEEN / STEERING SYSTEM
Safety precautions / Mechanical (manual) steering system / Power steering system
/ Specifications
